پیوندهای مفید
اخبار و اعلانات
آمار
| تعداد نشریات | 158 |
| تعداد شمارهها | 6,229 |
| تعداد مقالات | 67,748 |
| تعداد مشاهده مقاله | 115,091,583 |
| تعداد دریافت فایل اصل مقاله | 89,839,209 |
An Artificial Neural Network Model for Predicting the Pressure Gradient in Horizontal Oil–Water Separated Flow | ||
| Journal of Chemical and Petroleum Engineering | ||
| مقاله 6، دوره 49، شماره 2، اسفند 2015، صفحه 131-141 اصل مقاله (815.43 K) | ||
| نوع مقاله: Research Paper | ||
| شناسه دیجیتال (DOI): 10.22059/jchpe.2015.1808 | ||
| نویسندگان | ||
| Sadra Azizi؛ Hajir Karimi* | ||
| Department of Chemical Engineering, Yasouj University, Yasouj, I. R. Iran | ||
| چکیده | ||
| In this study, a three–layer \ artificial neural network (ANN) model was developed to predict the pressure gradient in horizontal liquid–liquid separated flow. A total of 455 data points were collected from 13 data sources to develop the ANN model. Superficial velocities, viscosity ratio and density ratio of oil to water, and roughness and inner diameter of pipe were used as input parameters of the network while corresponding pressure gradient was selected as its output. A tansig and a linear function were chosen as transfer functions for hidden and output layers, respectively and Levenberg–Marquardt back–propagation algorithm were applied to train the ANN. The optimal topology of the ANN was achieved with 16 neurons in hidden layer, which made it possible to estimate the pressure gradient with a good accuracy (R2=0.996 &AAPE=7.54%). In addition, the results of the developed ANN model were compared to Al–Wahaibi correlation results (with R2=0.884&AAPE=17.17%) and it is found that the proposed ANN model has higher accuracy. Finally, a sensitivity analysis was carried out to investigate the relative importance of each input parameter on the ANN output. The results revealed that the pipe diameter (D) has the most relative importance (24.43%) on the ANN output, while the importance of the other parameters is nearly the same. | ||
| کلیدواژهها | ||
| Liquid–liquid flow؛ Pressure gradient؛ Oil–water separated flow؛ Artificial Neural Network | ||
| مراجع | ||
|
[1] Xu, X. (2007). “Study on oil-water two-phase flow in horizontal pipelines.” J. Pet. Sci. Eng., Vol. 59, pp43–58.
[2] Bannwart, A.C., Rodriguez, O.M.H., de Carvalho, C.H.M., Wang, I.S., Vara, R.M.O. (2004). “Flow patterns in heavy crude oil-water flow.” J. Energy. Res. Technol. Trans., Vol. 126, No. 3, pp. 184–189.
[3] Charles, M.E., Govier, G.W., Hodgson, G.W. (1961). “The horizontal pipeline flow of equal density oil-water mixtures.” Can. J. Chem. Eng., pp. 27–36.
[4] Mandal, T.K., Chakrabarti, D.P., Das, G. (2007). “Oil water flow through different diameter pipes–similarities and differences.” Trans. IchemE. Part A. Chem. Eng. Res. Des., Vol. 85, No. A8, pp. 1123–1128.
[5] Wegmann, A., von Rohr, P.R. (2006). “Brief communication: two-phase liquid-liquid flows in pipes of small diameters.” Int. J. Multiphase Flow, Vol. 32, pp. 1017–1028.
[6] Lockhart, R.W., Martinelli, R.C. (1949). “Proposed correlation of data for isothermal two-phase, two-component flow in pipes.” Chem. Eng. Prog., Vol. 45, pp. 39–48.140
[7] Charles, M.E., Lilleleht, L.U. (1966). “Correlation of pressure gradients for the stratified laminar turbulent pipeline flow of two immiscible liquids.” Can. J. Chem. Eng., Vol. 44, pp. 47–49.
[8] Stapelberg, H.H., Mewes, D. (1994). “The pressure loss and slug frequency of liquid–liquid–gas slug flow in horizontal pipes.” Int. J. Multiphase Flow, Vol. 20, pp. 285–303.
[9] Angeli, P., Hewitt, G.F. (1998). “Pressure gradient in horizontal liquid–liquid flows.” Int. J. Multiphase Flow, Vol. 24, No. 7, pp. 1183–1203.
[10] Chakrabarti, D.P., Das, G., Ray, S. (2005). “Pressure drop in liquid-liquid two-phase horizontal flow: experiments and prediction.” Chem. Eng. Technol., Vol. 28, pp. 1003–1009.
[11] Rodriguez, O.M.H., Oliemans, R.V.A. (2006). “Experimental study on oil-water flow in horizontal and slightly inclined pipes.” Int. J. Multiphase Flow, Vol. 32, pp. 323–343.
[12] Yiping, L., Hua, Z., Shuhua, W., Jing, W. (2008). “Prediction of pressure gradient and hold up in small Eötvös number liquid-liquid segregated flow.” Chinese J. Chem. Eng., Vol. 16, No. 2, pp. 184–191.
[13] Al–Wahaibi, T. (2012). “Pressure gradient correlation for oil-water separated flow in horizontal pipes, Exp. Therm. Fluid Sci., Vol. 42, pp. 196–203.
[14] Zhang, G., Patuwo, B.E., Hu, M.Y. (2002). “Forecasting with artificial neural networks: to optimum bit selection.” Comput. Geosci., Vol. 28, pp. 131–141.
[15] Sablani, S.S., Shayyab, W.H., Kacimovc, A. (2003). “Explicit calculation of the friction factor in pipeline flow of Bingham plastic fluids: a neural network approach.” Chem. Eng. Sci., Vol. 58, pp. 99–106.
[16] Goutorbe, B., Lucazeau, F., Bonneville, A. (2006). “Using neural networks to predict thermal conductivity from geophysical well logs, Artificial neural network for the evaluation of CO2 corrosion in a pipeline steel.” Geophys. J. Int., Vol. 166, pp. 115–125.
[17] Bassam, A., Ortega–Toledo, D., Hernández, J.A., González–Rodriguez, J.G., Uruchurtu, J. (2009). “Artificial neural network for the evaluation of CO2 corrosion in a pipeline steel.” J. Solid State Electr., Vol. 13, pp. 773–780.
[18] Osman, E.A., Aggour, M.A. (2002). “Artificial Neural Network Model for Accurate Prediction of Pressure Drop in Horizontal and Near–Horizontal–Multiphase Flow.” Pet. Sci. Technol., Vol. 20, No. 1–2, pp. 1–15.
[19] Osman, E.A. (2001). “Artificial Neural Networks Models for Identifying Flow Regimes and PredictingLiquid Holdup in Horizontal Multiphase Flow.” SPE Middle East Oil and Gas Show and Conf., Bahrain, 68219.
[20] Shippen, M.E., Scott, S.L. (2002). “A Neural Network Model for Prediction of Liquid Holdup in Two-Phase Horizontal Flow.” SPE J., 77499.
[21] Malayeri, M.R., Steinhagen, H.M., Smith, J.M. (2003). “Neural network analysis of void fraction in
air/water two-phase flows at elevated temperatures.” Chem. Eng. Process, Vol. 42, pp. 587–597.
[22] del Castillo, A.Á., Santoyo, E., García–Valladares, O. (2012). “A new void fraction correlation inferred from artificial neural networks for modeling two-phase flows in geothermal wells.” Comput. Geosci., Vol. 41, pp. 25–39.
[23] Sharma, H., Das, G., Samanta, A.N. (2006). “ANN–based prediction of two-phase gas-liquid flow patterns in a circular conduit.” AIChE. J., Vol. 52, pp. 3018–3028.
[24] Al–Naser, M., Elshafei, M. (2015). “Two-phase flow regimes identification using artificial neural network with nonlinear normalization.” proceedings of the 2nd international conference on fluid flow, Heat and Mass Transfer Ottawa, Ontario, Canada.
[25] Shirley, R., Chakrabarti, D.P., Das, G. (2012). “Artificial neural networks in liquid-liquid two-phase flow.” Chem. Eng. Commun., Vol. 199, pp. 1520–1542.
[26] Raj, T.S., Chakrabarti, D.P., Das, G. (2005). “Liquid-liquid stratified flow through horizontal conduit.”Chem. Eng. Technol., Vol. 28, pp. 899–907.
[27] Dasari, A., Desamala, A.B., Dasmahapatra, A.K., Mandal, T.K. (2013). “Experimental studies and probabilistic neural network prediction on flow pattern of viscous oil-water flow through a circular horizontal pipe.” Ind. Eng. Chem. Res., Vol. 52, No. 23, pp. 7975–7985.
[28] Al–Wahaibi, T. Smith, M., Angeli, P. (2007). “Effect of drag–reducing polymers on horizontal oil-water flows.” J. Pet. Sci. Eng., Vol. 57, No. 3–4, pp. 334–346.
[29] Al–Yaari, M., Soleimani, M.A., Abu–Sharkh, B., Al–mubaiyedh, U., Al–sarkhi, A. (2009). “Effect of drag reducing polymers on oil-water flow in a horizontal pipe.” Int. J. Multiphase Flow, Vol. 35, pp. 516–524.
[30] Elseth, G. (2001). “An experimental study of oil-water flow in horizontal pipes, Ph.D. Thesis, The Norwegian University of Science and Technology, Porsgrunn.
[31] Nädler, M., Mewes, D. (1997). “Flow-induced emulsification in the flow of two immiscible liquids in horizontal pipes.” Int. J. Multiphase Flow, Vol. 23, pp. 55–68.
[32] Ravi, P., Sharma, M. Gosh, Das, G., Das, G.P.K. (2010). “Effects of return bands on kerosene– water flow through a horizontal pipe.” 7th Int. Conf. on Multiphase Flow, ICMF 2010, Tampa, Florida. USA.
[33] Trallero, J.L. (1995). “Oil–water flow patterns in horizontal pipes.” Ph.D. Thesis, University of Tulsa. USA.
[34] Valle, A., Kvandal, H. (1995). “Pressure drop and dispersion characteristics of separated oil/water flow.” Two-Phase Flow Model Exp., pp. 583–592.
[35] Yousuf, N. (2011). “Experimental study in horizontal oil-water flow.” Ph.D. Thesis, Ahmadu Bello University, Nigeria.
[36] Razavi, M.A., Mortazavi, A., Mousavi, M. (2003). “Dynamic modeling of milk ultrafiltration by artificial neural network.” J. Membrane Sci., Vol. 220, pp. 47–58.
[37] Saini, L.M., Soni, M.K. (2002). “Artificial neural network based peak load forecasting using Levenberg Marquardt and quasi-Newton methods.” IEE Proceedings of Generation, Trans. Distrib., Vol. 149, pp. 578–584.
[38] Hush, D., Horne, B.G. (1993). “Progress in supervised neural networks.” IEEE Signal Proc. Mag., Vol. 10, pp. 8–39.
[39] Karimi, H., Yousefi, F., Rahimi, M.R. (2011). “Correlation of viscosity in nanofluids using genetic algorithm–neural network (GA–NN).” Heat Mass Transfer, Vol. 47, pp. 1417–1425.
[40] Zigrang, D.J., Sylvester, N.D. (1985). “A review of explicit friction factor equations.” J. Energ. Res. Technol., Vol. 107, pp. 280–283.
[41] Dukler, A.E., Wicks, M., Cleveland, R.G. (1964). “Pressure drop and hold–up in two-phase flow.” AIChE. J., Vol. 10, pp. 38–51.
[42] Garson, G.D. (1991). “Interpreting neural–network connection weights.” A.I. Expert., Vol. 6, pp. 46–51 | ||
|
آمار تعداد مشاهده مقاله: 1,973 تعداد دریافت فایل اصل مقاله: 1,389 |
||