پیوندهای مفید
اخبار و اعلانات
آمار
| تعداد نشریات | 161 |
| تعداد شمارهها | 6,532 |
| تعداد مقالات | 70,502 |
| تعداد مشاهده مقاله | 124,116,940 |
| تعداد دریافت فایل اصل مقاله | 97,221,778 |
Utilization of fermented whey protein concentrate and whey permeate in beard loaf making | ||
| Journal of Food and Bioprocess Engineering | ||
| دوره 4، شماره 2، اسفند 2021، صفحه 186-192 اصل مقاله (637.06 K) | ||
| نوع مقاله: Original research | ||
| شناسه دیجیتال (DOI): 10.22059/jfabe.2021.335604.1102 | ||
| نویسندگان | ||
| Hossein Jooyandeh* 1؛ Kuldip Singh Minhas2 | ||
| 1Department of Food Science and Technology, Associate professor, Agricultural Sciences and Natural Resources University of Khuzestan, Mollasani, Iran | ||
| 2Department of Food Science and Technology, Punjab Agricultural University, Ludhiana, Punjab, India | ||
| چکیده | ||
| The fermented whey protein concentrate (FWPC) and whey permeate (WP) at the levels of 0 (control), 25, 50, 75 and 100% were separately substituted instead of water (v/v) used for dough preparation in bread loaf making. The effect of incorporation of WP or FWPC was measured on dough properties (falling number, dough handling and water absorption) and bread making quality (loaf volume, loaf height, specific volume and baking loss). The results clearly showed that incorporation of increasing amount of WP and FWPC had contrary effect on falling number and significantly reduced and increased falling number values, respectively. Incorporation of WP and FWPC at increasing levels during dough preparation showed significant increase in water absorption in comparison to control and handling of dough for all treatments was smooth except for samples contain 100% FWPC which the dough was slightly sticky. Increasing WP up to 50% increased volume, height and specific volume of loaves (p>0.05) and thereafter slightly reduced it, while increasing the level of FWPC, except at level 25%, progressively decreased these parameters (p < 0.05). Independent of whey type (WP or FWPC) and incorporation levels, baking loss of bread decreased significantly with WP or FWPC fortification compared to the control, indicating higher moisture retained in supplemented breads. Based on results of this study, by incorporation of 50% WP or 25% FWPC, a loaf bread could be produced with the appropriate dough properties (with smooth and flexible texture) and baking qualities (acceptable loaf volume and baking loss). | ||
| کلیدواژهها | ||
| FWPC؛ WP؛ Dough handling؛ Loaves؛ Bread quality | ||
| مراجع | ||
|
AACC (2010). American Association of Cereal Chemists Approved methods of Analysis. St. AACC International, St. Paul, MN.
AOAC (2000) Official Methods of Analysis. 17th ed, Association of Official Analytical Chemists. Gaithersburg, Maryland, USA.
Brar, R. S. (2000). Utilization of by-products of milk and soymilk in value added baked products. Ph.D. dissertation, Punjab Agricultural University, Ludhiana, India.
Danesh, E., Goudarzi, M., & Jooyandeh, H. (2017). Effect of whey protein addition and transglutaminase treatment on the physical and sensory properties of reduced-fat ice cream. Journal of Dairy Science, 100, 5206–5211.
Danesh, E., Goudarzi, M., & Jooyandeh, H. (2018). Transglutaminase-mediated incorporation of whey protein as fat replacer into the formulation of reduced-fat Iranian white cheese: physicochemical, rheological and microstructural characterization. Journal of Food Measurement and Characterization, 12(4), 2416-2425.
Erdogdu-Arnoczky, N., Czuchajowska, Z., & Pomeranz, Y. (1996). Functionality of whey and casein in fermentation and in breadmaking by fixed and optimized procedures. Cereal Chemistry 73(3), 309-316.
Farkye, N. Y., & Vedamuthu, N. (2002). Microbiology of soft cheese. In: Robinson R K (3rd ed) Dairy Microbiology Handbook. pp 491-493. John Wiley & Sons INC Publication, New York.
Ferreyra, L. S., Verdini, R. A., Soazo, M., & Piccirilli, G. N. (2021). Impact of whey protein addition on wheat bread fermented with a spontaneous sourdough. International Journal of Food Technology, 56(9), 4738-4745.
Gelinas, P., & Lachance, O. (1995). Development of fermented dairy ingredients as flavor enhancers for bread. Cereal Chemistry, 72(1), 17-21.
Gonçalves, C. M., Batista de Souza, C. H., Suguimoto, H. H., Ishii, P. L., & dos Santos, F. L. (2017). Addition of whey protein in bread-making: textural parameters and antioxidant potential of leavened and unleavened bread. International Journal of Food Engineering, 13(4), 20160218.
Irvine, G. N. & MacMullan, M. E. (1960). The remix baking test. Cereal Chemistry, 37, 603-613.
Jayaprakasha, H. M., & Brueckner, H. (1999). Whey protein concentrate: A potential functional ingredient for food industry. Journal of Food Science and Technology, 36(3), 189-204.
Jooyandeh, H. & Minhas, K. S. (2009). Effect of addition of fermented whey protein concentrate on cheese yield and fat and protein recoveries of feta cheese. Journal of Food Science and Technology, 46(3), 221-224.
Jooyandeh, H. (2009a). Effect of addition of fermented whey protein concentrate on texture of iranian white cheese. Journal of Texture Studies, 40, 497-510.
Jooyandeh, H. (2009b). Evaluation of physical and sensory properties of iranian lavash flat bread supplemented with precipitated whey protein (PWP). African Journal of Food Science, 3(2), 028 -034.
Jooyandeh, H., Minhas, K. S. & Kaur, A. (2009). Sensory quality and chemical composition of wheat breads supplemented with fermented whey protein concentrate and whey permeate. Journal of Food Science and Technology, 46(2), 146-148.
Kadharmestan, C., Baik, B. K. & Czuchajowska, Z. (1998). Whey protein concentrate treated with heat or high hydrostatic pressure in wheat-based products. Cereal Chemistry, 75(5), 762-766.
Kenny, S., Wehrle, K., Stanton C., & Arendt E. K. (2000). Incorporation of dairy ingredients into wheat bread: effects on dough rheology and bread quality. European Food Research and Technology, 210, 391-396.
Kim, H. J., Morita, N., Lee, S. H., & Moon, K. D. (2003). Scanning electron microscopic observations of dough and bread supplemented with Gastrodia elata blume powder. Food Research International, 36, 387–389.
Kouravand, F., Jooyandeh, H., Barzegar, H., & Hojjati, M. (2017). Characterization of cross‐linked whey protein isolate‐based films containing Satureja khuzistanica Jamzad essential oil. Journal of Food processing and preservation, 42(3), e13557, 1-10.
Lee, H., Song, M., Yu, Y., & Hwang, S. (2003). Production of Ganoderma lucidum mycelium using cheese whey as an alternative substrate: response surface analysis and biokinetics. Biochemical Engineering Journal, 15, 93–99.
Lupano, C. (2000). Gelation of mixed systems whey protein concentrate-gluten in acidic conditions. Food Research International, 33, 691–696.
Nooshkam, M., Babazadeh A., & Jooyandeh, H. (2018). Lactulose: Properties, techno-functional food applications, and food grade delivery system. Trends in Food Science & Technology, 80, 23-34.
Rantamäki, P., Tossavainen, O., Outinen, M., Tupasel, T., Koskinen, P. et al. (2006). Food applications of the whey protein fractions produced in pilot scale processes. I. Bread. Milchwissenschaft, 61(1), 65-68.
Renner, E. & Abd El-Salam, M. H. (1991). Application of ultrafiltration in the dairy Industry. Elsevier Applied Science, London.
Singh, H., & MacRitchie, F. (2001). Application of polymer science to properties of gluten. Journal of Cereal Science, 33, 231-243.
Torabi, F., Jooyandeh, H., & Noshad, M. (2021). Evaluation of physicochemical, rheological, microstructural, and microbial characteristics of synbiotic ultrafiltrated white cheese treated with transglutaminase. Journal of Food Processing and Preservation, 45, e15572, 1-11.
van Riemsdijk, L. E., van der Goot, A. J., Hamer, R. J., & Boom, R. M. (2011). Preparation of gluten free bread using a meso-structured whey protein particle system. Journal of Cereal Science. 53, 355-361.
Warren A. B., Hnat D. L. & Michnowski, J. (1983). Protein fortification of cookies, crackers, and snack bars: uses and needs. Cereal Foods World, 28, 441–444.
Yu, Y., Wanga, L., Qiana, H., Zhanga, H. & Qia, X. (2018). Contribution of spontaneously-fermented sourdoughs with pear and navel orange for the bread-making. LWT - Food Science and Technology, 89, 336–343. | ||
|
آمار تعداد مشاهده مقاله: 280 تعداد دریافت فایل اصل مقاله: 344 |
||