پیوندهای مفید
اخبار و اعلانات
آمار
| تعداد نشریات | 158 |
| تعداد شمارهها | 6,225 |
| تعداد مقالات | 67,685 |
| تعداد مشاهده مقاله | 114,943,860 |
| تعداد دریافت فایل اصل مقاله | 89,611,908 |
Comparison and Optimization of Pyrolysis Bio-Oil Composition from Sewage Sludge and Spirulina Microalgae | ||
| Journal of Chemical and Petroleum Engineering | ||
| دوره 57، شماره 1، شهریور 2023، صفحه 133-147 اصل مقاله (592.41 K) | ||
| نوع مقاله: Research Paper | ||
| شناسه دیجیتال (DOI): 10.22059/jchpe.2023.356505.1425 | ||
| نویسندگان | ||
| Reza Hemmatkhah1؛ Nasrolla Majidian1؛ Ahmad Hallajisani* 2؛ Mohammad Samipoor giri1 | ||
| 1Department of Chemical Engineering, Faculty of Engineering, North Tehran branch, Islamic Azad University, Tehran, Iran | ||
| 2Caspian faculty of Engineering, College of Engineering, University of Tehran | ||
| چکیده | ||
| The abundant presence of spirulina microalgae and sewage sludge led to the researchers pay attention to recycling and economical conversion into valuable materials. This study investigated the simultaneous pyrolysis composition of two materials, spirulina microalgae and sewage sludge and also the factors affecting of the production of bio-oil from them. The effect of temperature, weight ratio of spirulina to SS, and the heating rate was investigated with the help of Design Expert software. Optimal conditions for pyrolysis was obtained at 519.3 °C, the weight ratio of 0.73 and heating rate of 17.9 °C/min and bio-oil production yield also was obtained 69.35%. The heat value of bio-oil was obtained at 25.52 MJ/kg and its energy efficiency was 66.3%. The results showed that with increasing in the temperature, aromatic content that enhance the heat value were increased. Also, by directing the reaction to optimal conditions, the oxygenated and nitrogenous compounds in the bio-oil were reduced. The simultaneous combination of spirulina and SS increases the number of aromatic substances and decreases oxygenated and nitrogenous group spirulina in bio-oils. It is expected to obtain suitable liquid fuel and chemical substances by pyrolysis of various biomasses. | ||
| کلیدواژهها | ||
| Bio-Oil comparison؛ Pyrolysis؛ Spirulina؛ Sewage sludge؛ Yield Production؛ Optimization | ||
| مراجع | ||
|
[1] Laskar N, Kumar U . Plastics and microplastics: A threat to environment. Environ. Technol. Innov,2019;14: 100352. https://doi.org/10.1016/j.eti.2019.100352 [2] Rai P. K, Lee J, Brown R. J. CEnvironmental fate, ecotoxicity biomarkers, and potential health effects of micro- and nano-scale plastic contamination,” J. Hazard. Mater. 2021; 403:123910. https://doi.org/10.1016/j.jhazmat.2020.123910 [3] Dushyant Kumar, Chhaya Sharma, Paper industry wastewater treatment by electrocoagulation and aspect of sludge management, Journal of Cleaner Production, Volume 360, 2022, 131970, ISSN 0959-6526, https://doi.org/10.1016/j.jclepro.2022.131970. [4] Arefin M. R Infrastructural Discontent in the Sanitary City: Waste, Revolt, and Repression in Cairo,” Antipode.2019;51: 1057–1078. https://doi.org/10.1111/anti.12562 [5] Rao M. D, K. Singh K, Morrison C. A, Love J. B . Challenges and spirulina microalgae opportunities in the recovery of gold from electronic waste,” RSC Adv. 2020; 10:4300–4309. DOI: 10.1039/c9ra07607g [6] Prabhakar A, Mishra S, Das A. P Isolation and Identification of Lead (Pb) Solubilizing Bacteria from Automobile Waste and Its Potential for Recovery of Lead from End of Life Waste Batteries,” Geomicrobiol. J. 2019; 36: 894–903. https://doi.org/10.1080/01490451.2019.1654044 [7] Jang YC, Lee G, Kwon Y, Hong Lim J, hyun Jeong J. Recycling and management practices of plastic packaging waste towards a circular economy in South Korea,” Resour. Conserv. Recycl., 2020; 158: 104798. https://doi.org/10.1016/j.resconrec.2020.104798 [8] Tallentire C. W, Steubing B. The environmental benefits of improving packaging waste collection in Europe,” Waste Manag., 2020; 103: 426–436 . https://doi.org/10.1016/j.wasman.2019.12.045 [9] Spooren et al J .Near-zero-waste processing of low-grade, complex primary ores and secondary raw materials in Europe: technology development trends,” Resour. Conserv. Recycl., 2020; 160: 104919, 2020 .https://doi.org/10.1016/j.resconrec.2020.104919 [10] N. Duan et alComparative study of municipal solid waste disposal in three Chinese representative cities,” J. Clean. Prod. 2020;254: 120134. https://doi.org/10.1016/j.jclepro.2020.120134 [11] Wang Z, Burra K. G, Lei T, Gupta A. K Co-pyrolysis of waste plastic and solid biomass for synergistic production of biofuels and chemicals-A review,” Prog. Energy Combust. Sci. 2021; 84: 100899. https://doi.org/10.1016/j.pecs.2020.100899 [12] Elkhalifa S, Al-Ansari T, Mackey H. R, G. McKay Food waste to biochars through pyrolysis: A review,” Resour. Conserv. Recycl., 2019; 144: 310–320. https://doi.org/10.1016/j.resconrec.2019.01.024 [13] Liu J, Huang S, Chen K, Wang T, Mei M, Li J Preparation of biochar from food waste digestate: Pyrolysis behavior and product properties,” Bioresour. Technol. 2020; 302: 122841. https://doi.org/10.1016/j.biortech.2020.122841 [14] Maqsood T, Dai J, Guang Y. M, Li B Pyrolysis of plastic species: A review of resources and products J Anal. Appl. Pyrolysis. 2021; 159: 105295. https://doi.org/10.1016/j.jaap.2021.105295 [15] Moazezi M. R, Bayat H, Tavakoli O, Hallajisani A. Hydrothermal liquefaction of Chlorella vulgaris and catalytic upgrading of product: Effect of process parameter on bio-oil yield and thermodynamics modeling." Fuel .2022; 318: 123595. https://doi.org/10.1016/j.fuel.2022.123595 [16] Fang J et al . Thermochemical liquefaction of cattle manure using ethanol as solvent: Effects of temperature on bio-oil yields and chemical compositions,j Renewable Energy 2021; 167: 32-41. https://doi.org/10.1016/j.renene.2020.11.033 [17] Ouedraogo A. S, Bhoi PR, Gerdmann C, Patil V, Adhikari S . Improving hydrocarbons and phenols in bio-oil through catalytic pyrolysis of pine sawdust,” J. Energy Inst. 2021; 99:9–20 . https://doi.org/10.1016/j.joei.2021.07.014 [18] Quesada L, Pérez A, Godoy V, Peula F. J, Calero M, Blázquez G “Optimization of the pyrolysis process of a spirulina microalgae to obtain a liquid fuel using different mathematical models,” Energy Convers. Manag., 2019; 188: 19–26 https://doi.org/10.1016/j.enconman.2019.03.054 [19] Safarzadeh H, Peighambardoust S. J, Mousavi S. H, Mohammadi R, Peighambardoust S. H. Adsorption of methyl violet dye from wastewater using poly(methacrylic acid-co-acrylamide)/bentonite nanocomposite hydrogels,” J. Polym. Res. 2022; 29: 113. https://doi.org/10.1007/s10965-022-02956-0 [20] Sun.H et al. Characteristics of Gas-Liquid-Solid Products in Corn Straw Gasification: Effect of the Char-Tar-H2O Interaction,” Energy and Fuels, 2019; 33: 9974–9984. https://doi.org/10.1021/acs.energyfuels.9b02682 [21] Salem S. M. Al, Dutta A .Wax Recovery from the Pyrolysis of Virgin and Waste Plastics,” Ind. Eng. Chem. Res. 2021; 60: 8301–8309. https://doi.org/10.1021/acs.iecr.1c01176 [22] Nuchdang S, Patthaveekongka W, Rattanaphra D.Effects of plastic film in a loosed powder form of sample preparation on elemental analysis by portable X-ray fluorescence spectrometer,” IOP Conf. Ser. Earth Environ. Sci .2019; 398. DOI 10.1088/1755-1315/398/1/012004 [23] Ferreira R. A. dos R, Meireles C. da S, Assunção R. M. N, Barrozo M. A. S, and Soares R. R. Optimization of the oxidative fast pyrolysis process of sugarcane straw by TGA and DSC analyses,” Biomass and Bioenergy. 2020;134: 1–7. https://doi.org/10.1016/j.biombioe.2019.105456 [24] Özsin G, Pütün AE. TGA/MS/FT-IR study for kinetic evaluation and evolved gas analysis of a biomass/PVC co-pyrolysis process,” Energy Convers. Manag., 2019; 182: 143–153. https://doi.org/10.1016/j.enconman.2018.12.060 [25] Zeng Q, Yao J, Shao J. Effect of plastic deformation on hydraulic fracturing with extended element method,” Acta Geotech. 2019: 14: 2083–2101. doi.org/10.1007/s11440-018-0748-0 [26] Miandad et al R. Influence of temperature and reaction time on the conversion of spirulina to pyrolysis liquid oil,” Waste Manag.2016; 58: 250–259. https://doi.org/10.1016/j.wasman.2016.09.023 [27] Kumagai S, Takahashi Y, Kameda T, Saito Y, Yoshioka T Quantification of cellulose pyrolyzates via a tube reactor and a pyrolyzer-gas chromatograph/flame ionization detector-based system,” ACS Omega. 2021; 6: 12022–12026. https://doi.org/10.1021/acsomega.1c00622 [28] Sun et al.Y Effects of feedstock type, production method, and pyrolysis temperature on biochar and hydrochar properties,” Chem. Eng. J., 2014; 240: 574–578. https://doi.org/10.1016/j.cej.2013.10.081 [29] Pourkarimi S, Hallajisani A, Alizadehdakhel A, Nouralishahi A. Biofuel production through micro- and macroalgae pyrolysis – A review of pyrolysis methods and process parameters,” J. Anal. Aspirulina microalgae. Pyrolysis, 2019; 142: 104599. https://doi.org/10.1016/j.jaap.2019.04.015 [30] Liu Y, Qian J, Wang J. Pyrolysis of spirulina waste in a fluidized-bed reactor to obtain styrene monomer and gasoline fraction,” Fuel Process. Technol. 2000; 63: 45–55. https://doi.org/10.1016/S0378-3820(99)00066-1 [31] Raza Hematkhah, Nasrollah Majidian, Ahmad Hallajisani, Mohammad Samipoorgiri, Investigation of catalytic pyrolysis of spirulina for bio-oil production, Arabian Journal of Chemistry, Volume 16, Issue 5, 2023, 104691. https://doi.org/10.1016/j.arabjc.2023.104691 | ||
|
آمار تعداد مشاهده مقاله: 194 تعداد دریافت فایل اصل مقاله: 191 |
||